Assessment of the effect of hydraulic retention time on the efficiency of waste treatment by co-digestion combined anaerobic membrane bioreactor through different reactor types
171 viewsDOI:
https://doi.org/10.54939/1859-1043.j.mst.VITTEP.2022.159-166Keywords:
Anaerobic membrane bioreactor (AnMBR); Anaerobic co-digestion; Organic solid waste; Domestic wastewater; Biogas production.Abstract
This study evaluates the influence of hydraulic retention time on the efficiency of domestic waste treatment by co-digestion technology combined with anaerobic membrane bioreactor through different types of reactors: continuous stirred tank reactor (CSTR-AnMBR) and upflow anaerobic sludge blanket (UASB-AnMBR). In the operating conditions of 2 models with average pH values from 6.8 to 7.4, the temperature is in the Mesophilic range, and the mixing ratio of domestic wastewater and organic solid waste is 5g/L. Change the water retention time parameters including 72 hours, 48 hours, 36 hours, and 24 hours, corresponding to organic loads: 0.67 kgCOD/m3.day, 1.00 kgCOD/m3.day, 1.33 kgCOD/m3.day and 2.00 kgCOD/m3.day. The results show that the COD treatment capacity at HRTs for the UASB-AnMBR model has a higher efficiency of 0.4% - 5.4%. In addition, the biogas production rate at the HRTs for the UASB-AnMBR model was higher than that of the CSTR-AnMBR model from 0.02 to 0.03 Lbiogas/gCODremoval. The corresponding methane generation rate is in the range of 0.01 - 0.02 Lbiogas/gCODremoval. The membrane transfer pressure value recorded in the experiment shows that the operating cycle of the membrane for the UASB tank is longer than 3.5 times than CSTR tank.
References
[1]. H. Yu, Z. Wang, Z. Wu and C. Zhu, "Enhanced waste activated sludge digestion using a submerged anaerobic dynamic membrane bioreactor: performance, sludge characteristics and microbial community," Scientific Reports, vol. 6, no. 20111, (2016). DOI: https://doi.org/10.1038/srep20111
[2]. G. Zeeman, K. Kujawa, T. d. Mes, L. Hernandez, M. d. Graaff, L. Abu-Ghunmi, A. Mels, B. Meulman, H. Temmink, C. B. J. v. Lier and G. Lettinga, "Anaerobic treatment as a core technology for energy, nutrients and water recovery from source-separated domestic waste(water)," Water Science & Technology, vol. 57, no. 8, pp. 1207-1212, (2008). DOI: https://doi.org/10.2166/wst.2008.101
[3]. S. Luostarinen and J. Rintala, "Anaerobic on-site treatment of kitchen waste in combination with black water in UASB-septic tanks at low temperatures," Bioresource Technology, vol. 98, no. 9, pp. 1734-1740, (2007). DOI: https://doi.org/10.1016/j.biortech.2006.07.022
[4]. J. W. Lim, "Anaerobic Co-digestion of Brown Water and Food Waste for Energy Recovery," in Urban waters: Resource or Risk? WWW-YES-2011, Arcueil, Prance, (2011).
[5]. Mengjiao Gao, Lei Zhang, Yang Liu, "High-loading food waste and blackwater anaerobic co-digestion: Maximizing bioenergy recovery," Chemical Engineering Journal, vol. 394, p. 124911, (2020). DOI: https://doi.org/10.1016/j.cej.2020.124911
[6]. Leitao, R. C, A. C van Haandel, G. Zeeman, G. Letting , "The effects of operation and environmental variations on anaerobic wastewater treatment systems: a review," Bioresource Technology , vol. 97, no. 9, pp. 1105-1118, (2006). DOI: https://doi.org/10.1016/j.biortech.2004.12.007
[7]. Han, Y., R. R. Dague, "Laboratory studies on the temperature-phased anaerobic digestion of domestic primary sludge," Water Environmental Resources, vol. 69, no. 6, pp. 1139-1143, (1997). DOI: https://doi.org/10.2175/106143097X125885
[8]. Simon M. Wandera; Wei Qiao; Mengmeng Jiang; Dalal E. Gapani; Shaojie Bi; Renjie, "AnMBR as alternative to conventional CSTR to achieve efficient methane production from thermal hydrolyzed sludge at short HRTs," Energy, vol. 159, pp. 588-598, (2018). DOI: https://doi.org/10.1016/j.energy.2018.06.201
[9]. M. Minale and T. Worku, "Anaerobic co-digestion of sanitary wastewater and kitchen solid waste for biogas and fertilizer production under ambient temperature: waste generated from condominium house," International Journal of Environmental Science and Technology, vol. 11, no. 2, pp. 509-516, (2014). DOI: https://doi.org/10.1007/s13762-013-0255-7
[10]. R. Cheerawit, T. S. Thunwadee, K. Duangporn, R. Tanawat and K. Wichuda, "Biogas Production from Co-digestion of Domestic Wastewater and Foof Waste," Health and The Environment Journal, vol. 3, no. 2, (2012).
