FABRICATION OF SELECTIVE NITROGEN-DIOXIDE GAS SENSOR IN MILITARY APPLICATIONS
220 viewsDOI:
https://doi.org/10.54939/1859-1043.j.mst.76.2021.120-126Keywords:
Gas sensor; Explosive gas; NO2.Abstract
In this work, we presented the results of research and manufacture of NO2 explosion detection gas sensors for military application. The gas sensor was fabricated based on Zn2SnO4 semiconductor metal oxide material. The results of material analysis, sensor fabrication, and measurement of NO2 sensitivity have been carried out. The results showed that the manufactured gas sensor was capable of detecting NO2 explosives with low concentration, suitable for military applications such as ammunition depots, gunpowder depots, mines.
References
[1]. K. M. S. et al., “Sputter deposited p-NiO/n-SnO2 porous thin film heterojunction based NO2 sensor with high selectivity and fast response,” Sensors Actuators B Chem., Vol. 310 (2020), p. 127830.
[2]. H. S. Jeong et al., “Low temperature NO2 sensing properties of RF-sputtered SnO-SnO2 heterojunction thin-film with p-type semiconducting behavior,” Ceram. Int., Vol. 44 (2018), pp. 17283–17289.
[3]. M. Akiyama et al., “Tungsten Oxide-Based Semiconductor Sensor Highly Sensitive to NO and NO2,” Chem. Lett., Vol. 20 (1991), pp. 1611–1614.
[4]. M. A. Patil et al., “Fast response and highly selective nitrogen dioxide gas sensor based on Zinc Stannate thin films,” Mater. Sci. Energy Technol., Vol. 3 (2020), pp. 36–42.
[5]. H. X. Thanh et al., “On-chip growth of single phase Zn2SnO4 nanowires by thermal evaporation method for gas sensor application,” J. Alloys Compd., Vol. 708 (2017), pp. 470–475.
[6]. N. H. Hanh et al. , “A comparative study on the VOCs gas sensing properties of Zn2SnO4 nanoparticles, hollow cubes, and hollow octahedra towards exhaled breath analysis,” Sensors Actuators B Chem., Vol. 343 (2021), p. 130147.
[7]. D. An et al., “Synthesis of Zn2SnO4 via a co-precipitation method and its gas-sensing property toward ethanol,” Sensors Actuators B Chem., Vol. 213 (2015), pp. 155–163.
[8]. T. Tharsika et al., “Gas sensing properties of zinc stannate (Zn2SnO4) nanowires prepared by carbon assisted thermal evaporation process,” J. Alloys Compd., Vol. 618 (2015), pp. 455–462, Jan. 2015.
[9]. D. An et al., “Ethanol gas-sensing characteristic of the Zn2SnO4 nanospheres,” Ceram. Int., Vol. 42 (2016), pp. 3535–3541.
[10]. G. Ma et al., “Phase-controlled synthesis and gas-sensing properties of zinc stannate (ZnSnO3 and Zn2SnO4) faceted solid and hollow microcrystals,” CrystEngComm, Vol. 14 (2012), p. 2172.
[11]. D. L. Young et al., “Structural characterization of zinc stannate thin films,” J. Appl. Phys., Vol. 91 (2002), pp. 1464–1471.
[12]. S. Park et al., “Synthesis of Nanograined ZnO Nanowires and Their Enhanced Gas Sensing Properties,” ACS Appl. Mater. Interfaces, Vol. 4 (2012), pp. 3650–3656.
[13]. Z. Ai et al., “Photocatalytic removal of NO and HCHO over nanocrystalline Zn2SnO4 microcubes for indoor air purification,” J. Hazard. Mater., Vol. 179 (2010), pp. 141–150.
[14]. Y. F. Sun et al., “Metal Oxide Nanostructures and Their Gas Sensing Properties: A Review,” Sensors, Vol. 12 (2012), no. 3, pp. 2610–2631.
[15]. N. H. Hanh et al., “VOC gas sensor based on hollow cubic assembled nanocrystal Zn2SnO4 for breath analysis,” Sensors Actuators A Phys., Vol. 302 (2020), p. 111834.
[16]. M. Miyauchi et al., “Single crystalline zinc stannate nanoparticles for efficient photo-electrochemical devices,” Chem. Commun., Vol. 46 (2010), p. 1529.
[17]. H. M. Yang et al., “Synthesis of Zn2SnO4 hollow spheres by a template route for high-performance acetone gas sensor,” Sensors Actuators B Chem., Vol. 245 (2017), pp. 493–506.
[18]. V. V. Ganbavle et al., “Development of Zn2SnO4 thin films deposited by spray pyrolysis method and their utility for NO2 gas sensors at moderate operating temperature,” J. Anal. Appl. Pyrolysis, Vol. 107 (2014), pp. 233–241.
[19]. C. M. Hung et al., “Comparative effects of synthesis parameters on the NO2 gas-sensing performance of on-chip grown ZnO and Zn2SnO4 nanowire sensors,” J. Alloys Compd., Vol. 765 (2018), pp. 1237–1242.
[20]. I. S. Hwang et al., “Synthesis and gas sensing characteristics of highly crystalline ZnO–SnO2 core–shell nanowires,” Sensors Actuators B Chem., Vol. 148 (2010), pp. 595–600.
[21]. E. Zampiceni et al., “Mo influence on SnO2 thin films properties,” Thin Solid Films, Vol. 418 (2002), pp. 16–20.
